网站首页公司概况 企业荣誉 产品简介 应用行业 科技研发 工程案例 销售网络 联系我们 在线留言
公司简介
发展历史
公司战略
企业文化
全称:河南长兴建设集团材料有限公司
联系人:杨经理
手机:0393-3558666
电话:0393-3323666
地址:河南濮阳市赵村工业园
     首页 >> 产品简介
CX-08:环氧铁红防锈底漆防腐涂料
发布时间:2015/6/24 16:35:07 []人次

 

CX-08:环氧铁红防锈底漆
 
成分性能:由环氧树脂、防锈颜填料、助剂、溶剂等组成。
产品特点:具有良好的附着力和防锈性能,漆膜坚硬、耐磨、耐水性、耐盐雾性能优异。
适用范围:用于桥梁、港口等金属设施、化工设备、煤气柜及其他构件的防腐底漆。
施工说明:混合配比  底漆:固化剂=10:1     熟化时间:(25℃)30分钟
适用期:(25℃)6小时     施工方法:高压无气喷涂、手工刷涂、轴涂
稀释剂:CX-稀释剂   最大稀释量:≤5%    
涂装间隔:(25℃)最短12小时,最长无限制
表面处理:钢材表面需抛丸或喷砂处理,达到瑞典除锈标准Sa2.5级或手工除锈达瑞典除锈标准St3级
施工条件:施工温度在5℃以上,相对湿度应小于85%。雨、雪、雾天气不宜外施工。
后道配套涂料:防腐面漆、环氧面漆、面漆、丙烯酸面漆、聚氨酯面漆、环氧煤沥青、防腐涂料等。
注意事项:
1、涂料现用现配,静置30分钟后再使用。因锌粉比重大,使用时须将漆料充分搅拌均匀后再加固化剂搅拌均匀。
2、富锌底漆易形成锌盐,在涂装后道漆之前,需除去锌盐及污物,以免影响层间附着力。
3、涂料应存放与阴凉、通风、干燥处。并隔离火种。
4、施工现场应注意通风,雨、雪、雾天不宜户外施工。
Composition: epoxy resin, anti rust pigment and fillers, additives, solvents, etc..
Product features: with good adhesion and anti rust properties, film hardness, wear resistance, water resistance, salt spray resistance.
Scope of application: used for metal facilities such as bridge, port, chemical equipment, gas tank and other components.
Construction Description: mixing primer: =10:1 curing agent curing time: 30 minutes (25 C)
Application period: (25) 6 hours construction method: high pressure no gas spraying, manual brush, axis
CX-: maximum amount of diluent diluent dilution: less than 5%
Coating interval: (25) the shortest 12 hours, the longest no limit
Surface treatment: steel surfaces shall be shot or grit blasting to Sweden rust standard Sa2.5 or manual derusting of Sweden rust standard ST3
Construction condition: the construction temperature is above 5, the relative humidity should be less than 85%. Rain, snow, fog weather is not outside the construction.
After matching paint: anti-corrosion paint, epoxy paint, lacquer, acrylic paint, polyurethane paint, epoxy coal asphalt, anti-corrosion coating.
Note:
1, paint is used now, 30 minutes after the use of static. Because of zinc than the major, use paint should be fully mixing after adding curing agent mix.
2, easy to form zinc rich primer zinc salt, before painting the paint, to remove the zinc salt and dirt, so as not to affect the adhesion between the layers.
3, paint should be stored in a cool, ventilated, dry place. And isolated fire.
4, the construction site should pay attention to ventilation, rain, snow, fog days not outdoor construction.

 

下一个:CX-07:环氧云铁防腐涂料
上一个:CX-30:无机硅酸锌防腐涂料
页面功能【打印】【关闭