网站首页公司概况 企业荣誉 产品简介 应用行业 科技研发 工程案例 销售网络 联系我们 在线留言
公司简介
发展历史
公司战略
企业文化
全称:河南长兴建设集团材料有限公司
联系人:杨经理
手机:0393-3558666
电话:0393-3323666
地址:河南濮阳市赵村工业园
     首页 >> 产品简介
CX-09:环氧煤沥青防腐涂料
发布时间:2015/6/24 16:35:49 []人次

 

CX-09:环氧煤沥青防腐涂料
 
成分性能:由环氧树脂、煤焦沥青、颜填料、助剂、溶剂及固化剂等组成。
产品特点:漆膜具有良好的防锈性和耐化学介质的腐蚀性,并具有优异的绝缘性抗水渗透性;该涂料有常温型、低温型两种涂料,低温型涂料干燥速度快,施工方便,在-15℃天气情况下可正常施工。
适用范围:用于埋地管道的外壁防护。
施工说明:混合配比:底漆:固化剂=6:1;底漆:固化剂=10:1   
                  面漆:固化剂=6:1;面漆:固化剂=1:1   熟化时间:(25℃)20分钟   
适用期:(25℃)6小时    施工方法:高压无气喷涂、手工刷涂、轴涂
稀释剂:稀释剂  最大稀释量:≤5%  涂装间隔:(25℃)最短3小时,最长48小时;
表面处理 :钢材表面需抛丸或喷砂处理,达到瑞典除锈标准Sa2.5级或手工除锈标准St3级
施工条件:施工前应注意天气和温度的变化,雨、雪、雾天气或相对湿度应大于85%时不可施工。
保养期:待漆面施涂完成后,漆膜至少保养7天。
注意事项:1、施工时必须计划用料、随用随配。漆料按比例混合,充分搅拌后静置20分钟后再施涂,余料不能倒回原桶。
2、必须待前道漆表干后方可施涂下道漆。
3、缠绕玻璃纤维布必须平整张紧,网眼灌满涂料。
4、管道口处应注意清除泥土、水迹,回填土时应注意避免损伤防腐层。
5、涂层未完全固化前不得进行埋管施工,涂装后的防腐件在运输、吊装过程中应避免损伤,如有损伤应及时修补。
6、施工现场应注意通风,雨、雪、雾天不宜户外施工。
7、涂料应存放于阴凉、通风、干燥处,并隔绝火种。
 
Ingredients: performance is composed of epoxy resin, coal tar, fillers, additives, solvents and curing agent.
Product features: the film has good corrosion and chemical medium corrosion resistance, and has excellent insulation resistance to water permeability. The coating is a normal temperature, low temperature type two kinds of coatings, low temperature type paint drying speed, convenient construction, at - 15 DEG C weather conditions can be normal construction.
Scope of application: the outer wall protection for buried pipelines.
Construction Description: mix proportion: Primer: =6:1 primer: =10:1
Finish: =6:1 paint curing agent; curing agent: =1:1 ripening time: 20 minutes (25 C)
Application period: (25) 6 hours construction method: high pressure no gas spraying, manual brush, axis
The maximum amount of diluent: diluent dilution: less than 5% coating intervals: (25 C) a minimum of 3 hours, the longest 48 hours;
Surface treatment: steel surface blasting or sandblasting, derusting to Swedish standard Sa2.5 level or St3 level standard manual derusting
Construction conditions: the construction should pay attention to the weather and temperature changes, rain, snow, fog weather or relative humidity should be greater than 85% when the construction.
The maintenance period: to apply paint film is completed, at least 7 days of maintenance.
Note: 1, the construction must be planned materials, with the use of. Paint mixing, fully stirring for 20 minutes and then applied, more than expected not back to the original bucket.
2, must be to be before the road before the road can be applied to the front of the road paint.
3, winding glass fiber cloth must be flat tension, mesh filled with paint.
4, the pipeline should pay attention to the removal of soil, water mark, back filling, should pay attention to avoid damage to anti-corrosion layer.
5, the coating is not completely cured before the construction of the buried pipe is not allowed, the anti-corrosion coating in the transport, lifting process should avoid damage, such as damage should be repaired in time.
6, the construction site should pay attention to ventilation, rain, snow, fog days not outdoor construction.
7, paint should be stored in a cool, ventilated, dry place, and cut off the fire.

 

下一个:CX-08:环氧铁红防锈底漆防腐涂料
上一个:CX-30:无机硅酸锌防腐涂料
页面功能【打印】【关闭